Aylin ŞAKAR-DELİORMANLİ, Erdal ÇELİK, Mehmet POLAT

INVESTIGATION THE DRYING BEHAVIOR OF CERAMIC SUSPENSION DROPLETS

Drying is a major issue in wet processing ceramics. It has crucial effects on the final properties ceramics films especially produced by aqueous based tape casting. In this study structural evolution of ceramic suspension droplets were investigated during drying. Effect of binder concentration on the ring formation from droplets was tested. Results revealed that PMN:latex ratio have some influence on the particle migration and at high latex concentrations particle clusters were observed in the supersaturated region.

Anahtar Kelimeler:

xx

INVESTIGATION THE DRYING BEHAVIOR OF CERAMIC SUSPENSION DROPLETS

Keywords:

Drying, tape casting ceramic suspensions,

PDF

___

Meier, P.L., Urech L., and Gauckler, L.J., Tape Casting of Nanocrystallize Ceria Gadolinia Powder, Journal of the European Ceramic Society, Vol. 24, No.15, Pages 3753-3758, 2004.
Mistler, R.E., Tape Casting: Past, Present, Potential, American Ceramic Society Bulletin, Vol.77, No.10, Pages 82-86, 1998. .
Chiu, R.C. and Cima, M.J., Drying of Granular Ceramic Films: II, Drying Stress, Saturation Uniformity, Journal of the American Ceramic Society, Vol. 76, Pages 2769-2777, 1993.
Scherer, G.W., Theory of Drying, Journal of the American Ceramic Society, Vol. 73, No.1, Pages 3-14, 1990.
Scherer, G.W., Aging and Drying of Gels, Journal of Non-Crystalline Solids, Vol. 100, Pages 77-92, 1988.
Rahaman, M.N., Ceramic Processing and Sintering, (Marcel Dekker Inc., USA), 1995.
Lewis, J.A., Colloidal Processing of Ceramics, Journal of the American Ceramic Society, Vol. 83, No.10, Pages 2341-59, 2000.
Şakar-Deliormanlı, A., Çelik,E., and Polat, M., Thermal Analysis and Microstructural Characterization of Ceramic Green Tapes Prepared by Aqueous Tape Casting, Journal of Thermal Analysis and Calorimetry, (In press).
Şakar-Deliormanlı, A., Çelik,E., and Polat, M., Preparation of the Pb(Mg1/3Nb2/3)O3 Films by Aqueous Tape Casting, Journal of the European Ceramic Society, ( In press).
Hu, H., and Larson, R.G., Analysis of the Microfluid Flow in an Evaporating Sessile Droplet, Langmuir, Vol. 21, Pages 3963-3971, 2005.
Deegan, R.D., Bakajin, O., Dupont, T.F., Huber, G., Nagel, S.R., and Witten, T.A., Capillary Flow as the Cause of Ring Strains from Dried Liquid Drops, Nature, Vol. 389, Pages 827-829, 1997.
Martinez, C.J., Structure and Property Evolution during Film Formation from Binary Colloidal Suspensions, PhD Thesis, University of Illinois at Urbana Champaign, 2002.
Martinez, C.J., and Lewis, J., Rheological, Structural, and Stress Evolution of Aqueous Al2O3: Latex Tape Cast Layers, Journal of the American Ceramic Society, Vol. 85, No.10, Pages 2409-16, 2002.