Effects of hydrogen peroxide, temperature and treatment time on degradation properties of polyethersulfone ultrafiltration membrane

Effects of hydrogen peroxide, temperature and treatment time on degradation properties of polyethersulfone ultrafiltration membrane

Oxidative cleaning agents such as hydrogen peroxide $(H_2 O_2 )$ and sodium hypochlorite (NaClO) used in water and wastewater treatment play an important role in the degradation and rapid aging of the polymeric membranes. In addition, when the temperature is above the maximum operating range of the membrane, it negatively affects the membrane performance.$H_2 O_2 $ ,which is also known as a green and environmentally friendly strong oxidant because of releasing only water as a by-product, can provide good cleaning efficiency under temperature, but its influence on membrane aging is not fully understood. In this study, the aging of polyethersulfone (PES) ultrafiltration (UF) membrane using $H_2 O_2 $ under high-temperature conditions and degradation of the polymeric membrane were systematically investigated using response surface methodology (RSM). The effects of $H_2 O_2 $ concentration, temperature, and treatment time were tested on membrane flux, contact angle, pore size, and porosity for decomposed membrane. The results showed that normalized permeability was significantly changed approximately 2.34-folds by $H_2 O_2 $ concentration at an exposure dose of 5 mM and 373 K temperature. Moreover, the largest pore sizes as 161.23 nm and 160.73 nm were obtained at the conditions of 2.5 mM $H_2 O_2 $concentration and 373 K temperature. The lowest contact angle (54.76°) and porosity (61.88%) were obtained at the same conditions. The results depicted that $H_2 O_2 $ can be used for membrane cleaning with minimum membrane degradation at moderate conditions

___

  • 1. Cheng X, Zhou W, Li P, Ren Z, Wu D et al. Improving ultrafiltration membrane performance with pre-deposited carbon nanotubes/ nanofibers layers for drinking water treatment. Chemosphere 2019; 234: 545–557. doi: 10.1016/j.chemosphere.2019.06.090
  • 2. Walker S, Narbaitz RM. Hollow fiber ultrafiltration of Ottawa River water: Floatation versus sedimentation pre-treatment. Chemical Engineering Journal 2016; 288: 228–237. doi: 10.1016/J.CEJ.2015.11.064
  • 3. Shao S, Fu W, Li X, Shi D, Jiang Y et al. Membrane fouling by the aggregations formed from oppositely charged organic foulants. Water Research 2019; 159: 95–101. doi: 10.1016/j.watres.2019.05.004
  • 4. Li K, Wen G, Li S, Chang H, Shao S, et al. Effect of pre-oxidation on low pressure membrane (LPM) for water and wastewater treatment: A review. Chemosphere 2019; 231: 287–300. doi: 10.1016/j.chemosphere.2019.05.081
  • 5. Wang Z, Ma J, Tang CY, Kimura K, Wang Q et al. Membrane cleaning in membrane bioreactors: A review. Journal of Membrane Science 2014; 468: 276–307. doi: 10.1016/j.memsci.2014.05.060
  • 6. Regula C, Carretier E, Wyart Y, Gesan-Guiziou G, Vincent A et al. Chemical cleaning/disinfection and ageing of organic UF membranes: A review. Water Research 2014; 56: 325–365. doi: 10.1016/j.watres.2014.02.050
  • 7. Li K, Li S, Su Q, Wen G, Huang T. Effects of hydrogen peroxide and sodium hypochlorite aging on properties and performance of polyethersulfone ultrafiltration membrane. International Journal of Environmental Research and Public Health 2019; 16: 3972. doi: 10.3390/ijerph16203972
  • 8. Li K, Li S, Huang T, Dong C, Li J et al. Chemical Cleaning of Ultrafiltration Membrane Fouled by Humic Substances: Comparison between Hydrogen Peroxide and Sodium Hypochlorite. International Journal of Environmental Research and Public Health 2019; 16: 2568. doi: 10.3390/ijerph16142568
  • 9. Zou J, Cai H, Wang D, Xiao J, Zhou Z et al. Spectrophotometric determination of trace hydrogen peroxide via the oxidative coloration of DPD using a Fenton system. Chemosphere 2019; 224: 646–652. doi: 10.1016/j.chemosphere.2019.03.005
  • 10. Wang X, Hu T, Wang Z, Li X, Ren Y. Permeability recovery of fouled forward osmosis membranes by chemical cleaning during a longterm operation of anaerobic osmotic membrane bioreactors treating low-strength wastewater. Water Reserach 2017; 123: 505–512. doi: 10.1016/j.watres.2017.07.011
  • 11. Strugholtz S, Sundaramoorthy K, Panglisch S, Lerch A, Brügger A et al. Evaluation of the performance of different chemicals for cleaning capillary membranes. Desalination 2005; 179: 191–202. doi: 10.1016/j.desal.2004.11.067
  • 12. Ling R, Yu L, Pham TPT, Shao J, Chen JP et al. The tolerance of a thin-film composite polyamide reverse osmosis membrane to hydrogen peroxide exposure. Journal of Membrane Science 2017; 524: 529–536. doi: 10.1016/j.memsci.2016.11.041
  • 13. Yu L, Ling R, Chen JP, Reinhard M. Quantitative assessment of the iron-catalyzed degradation of a polyamide nanofiltration membrane by hydrogen peroxide. Journal of Membrane Science 2019; 588. doi: 10.1016/J.MEMSCI.2019.05.078
  • 14. Yu W, Graham N, Liu T. Prevention of UF membrane fouling in drinking water treatment by addition of $H_2O_2$ during membrane backwashing. Water Research 2019; 149: 394–405. doi: 10.1016/j.watres.2018.11.006
  • 15. Yabalak E. An approach to apply eco-friendly subcritical water oxidation method in the mineralization of the antibiotic ampicillin. Journal of Environmental Chemical Engineering 2018; 6 (6): 7132-7137. doi: 10.1016/j.jece.2018.10.010
  • 16. Yabalak E. Degradation of ticarcillin by subcritical water oxidation method: Application of response surface methodology and artificial neural network modeling. Journal of Environmental Science and Health, Part A 2018; 53: 975–985. doi: 10.1080/10934529.2018.1471023
  • 17. Yabalak E, Gizir AM. Treatment of agrochemical wastewater by subcritical water oxidation method: chemical composition and ion analysis of treated and untreated samples. Journal of Environmental Science and Health, Part A 2020; 55: 1424–1435. doi: 10.1080/10934529.2020.1805249
  • 18. Kleijnen JPC. Response Surface Methodology. International Series in Operations Research & Management Science 2015; 81–104.
  • 19. Yabalak E, Ozay Y, Gizir AM, Dizge N. Water recovery from textile bath wastewater using combined subcritical water oxidation and nanofiltration. Journal of Cleaner Production 2020; 290: 125207. doi: 10.1016/j.jclepro.2020.125207
  • 20. Roy S, Thongsukmak A, Tang J, Sirkar KK. Concentration of aqueous hydrogen peroxide solution by pervaporation. Journal of Membrane Science 2012; 389: 17-24. doi: 10.1016/j.memsci.2011.09.046.
  • 21. Lin YL, Zheng NY, Chen YS. Enhancing $H_2O_2$Tolerance and Separation Performance through the Modification of the Polyamide Layer of a Thin-Film Composite Nanofiltration Membrane by Using Graphene Oxide. Membranes 2021; 11: 592. doi: 10.3390/membranes11080592.
  • 22. Maran JP, Manikandan S, Thirugnanasambandham K, Nivetha CV, Dinesh R. Box–Behnken design based statistical modeling for ultrasound-assisted extraction of corn silk polysaccharide. Carbohydrate Polymers 2013; 92: 604–611. doi: 10.1016/j.carbpol.2012.09.020
  • 23. Yabalak E, Topaloğlu I, Gizir AM. Application of the eco-friendly subcritical water oxidation method in the degradation of epichlorohydrin, Journal of the Serbian Chemical Society 2019; 84 (7): 757–767.doi: 10.2298/JSC181208027Y
  • 24. Yabalak E. Treatment of agrochemical wastewater by thermally activated persulfate oxidation method: Evaluation of energy and reagent consumption. Journal of Environmental Chemical Engineering 2021; 9 (3): 105201. doi: 10.1016/j.jece.2021.105201
  • 25. Yabalak E, Külekçi B, Gizir AM. Application of ultrasound-assisted and subcritical water oxidation methods in the mineralisation of Procion Crimson H-EXL using response surface methodology and artificial neural network, Journal of Environmental Science and Health, Part A 2019; 54 (14): 1412–1422. doi: 10.1080/10934529.2019.1647749
  • 26. Abejo R, Garea A, Irabien A. Effective Lifetime Study of Commercial Reverse Osmosis Membranes for Optimal Hydrogen Peroxide Ultrapurification Processes. Industrial & Engineering Chemistry Research 2013; doi: 10.1021/ie402895p.
  • 27. Tsehaye MT, Velizarov S, Van der Bruggen B. Stability of polyethersulfone membranes to oxidative agents: A review. Polymer Degradation and Stability 2018; doi: 10.1016/j.polymdegradstab.2018.09.004.
Turkish Journal of Chemistry-Cover
  • ISSN: 1300-0527
  • Yayın Aralığı: 6
  • Yayıncı: TÜBİTAK
Sayıdaki Diğer Makaleler

Phytochemical composition and pharmacological activities of Teucrium polium L. collected from eastern Turkey

Fatih GÖGER, Gökalp İŞCAN, Mine KÜRKÇÜOĞLU, Ayşe CİVAŞ, K. Hüsnü Can BAŞER, Turgut TAŞKIN, Gülay ECEVİT GENÇ, Afife MAT, Gizem GÜLSOY TOPLAN

Synthesis, molecular modeling, and biological evaluation of novel imatinib derivatives as anticancer agents

Yuk Yin NG, Özlem ULUCAN, Fulya GÜNAY, Sevcan BALTA, Zuhal TURGUT, Ömer Tahir GÜNKARA

Investigation of antibacterial and photocatalytic efficiency of green ZnO nanoparticles that synthesized with Celosia Cristata flower extract

Özgür DUYGULU, Mahmure ÜSTÜN ÖZGÜR, Melda ALTIKATOĞLU YAPAÖZ

Capillary zone electrophoresis as a quality assessment tool of paracetamol and phenylephrine hydrochloride in presence of paracetamol impurities

Joliana F. FARID, Nadia M. MOSTAFA, Yasmin M. FAYEZ, Hebatallah M. ESSAM

First determination of anticancer, cytotoxic, and in silico ADME evaluation of secondary metabolites of endemic Astragalus leucothrix Freyn & Bornm

Melda DÖLARSLAN, İbrahim DEMİRTAŞ, Duygu GÜNEŞ GÜRBÜZ, Ayşe ŞAHİN YAĞLIOĞLU

Solar light degradation of organic dye pollutants and preparation of bis(indolyl) methanes using core-shell $Fe_3 O_4 @SiO_2 @CuO$ nanocomposite

Mina MIRZAEI, Kaveh PARVANAK BOROUJENI, Zeinab TOHIDIYAN

Synthesis of benzoyl hydrazones having 4-hydroxy-3,5-dimethoxy phenyl ring, their biological activities, and molecular modeling studies on enzyme inhibition activities

Gizem TATAR, Bedriye Seda KURŞUN AKTAR, Emine Elçin ORUÇ EMRE, Yusuf SICAK

Production of NiMn2O4 hollow spheres and $CoFe_2O_4$bowl-like structures by using block copolymer stabilized polystyrene spheres as a hard template

Vural BÜTÜN, Gökhan KOÇAK

Effects of hydrogen peroxide, temperature and treatment time on degradation properties of polyethersulfone ultrafiltration membrane

Nadir DİZGE, Erdal YABALAK, Yasin ÖZAY

Selective adsorption of acidic gases from ternary mixture by acetate- and sulfonate-based ionic liquids at molecular level

Sadiye VELİOĞLU