Parametric evaluation of solar integrated combined partial cooling supercritical CO2 cycle and Organic Rankine Cycle using low global warming potential fluids

Parametric evaluation of solar integrated combined partial cooling supercritical CO2 cycle and Organic Rankine Cycle using low global warming potential fluids

In this study, the performance of the organic Rankine cycle combined with the partial cooling supercritical CO2 cycle as the bottoming cycle for recovering the low grade heat powered by a solar power tower was evaluated. Ecofriendly fluids were taken into consideration. To simulate the model under consideration, a computer programme was created in engineering equation solver software. The impacts of solar radiation, concentration ratio, solar incidence angle, CO2 turbine inlet temperature, heat exchanger effectiveness and main compressor inlet tempera-ture were investigated. Based on working fluid R1224yd(Z), it was determined that the com-bined cycle’s thermal efficiency, exergy efficiency, and power output improved from 35.16% to 55.43%, 37.73% to 59.42%, and 188 kW to 298.5 kW, respectively, as solar irradiation raised from 0.4 kW/m2 to 0.95 kW/m2. Lower the solar incidence angle and higher the concentration ratio can enhance the combined system’s performance. Amongst the working fluids that were taken into account, R1224yd(Z) was suggested as having superior performance.

___

  • REFERENCES
  • [1] Praveen RP. Performance analysis and optimization of central receiver solar thermal power plants for utility scale power generation. Sustainability 2020;12:127. [CrossRef]
  • [2] Khan Y, Mishra RS. Thermo-economic analysis of the combined solar based pre-compression supercritical CO2 cycle and organic Rankine cycle using ultra low GWP fluids. Therm Sci Eng Prog 2021;23:100925. [CrossRef]
  • [3] Ahn Y, Bae SJ, Kim M, Cho SK, Baik S, Lee JI, et al. Review of supercritical CO2 power cycle technology and current status of research and development. Nucl Eng Technol 2015;47:647–661. [CrossRef]
  • [4] Liang Y, Sun Z, Dong M, Lu J, Yu Z. Investigation of a refrigeration system based on combined supercritical CO2 power and transcritical CO2 refrigeration cycles by waste heat recovery of engine. Int J Refrig 2020;118:470482. [CrossRef]
  • [5] Al-Sulaiman FA. Exergy analysis of parabolic trough solar collectors integrated with combined steam and organic Rankine cycles. Energy Convers Manag 2014;77:441–449. [CrossRef]
  • [6] Khatoon S, Kim M. Performance analysis of carbon dioxide based combined power cycle for concentrating solar power. Energy Conversion and Management. 2020;205:112416. [CrossRef]
  • [7] Song J, Li X, Wang K. Parametric optimization of a combined supercritical CO2 (sCO2) cycle and organic Rankine cycle (ORC) system for internal combustion engine (ICE) waste-heat recovery. Energy Convers Manag 2020;218:112999. [CrossRef]
  • [8] Khan Y, Mishra RS. Performance evaluation of solar based combined pre-compression supercritical CO2 cycle and organic Rankine cycle. Int J Green Energy 2021;18:172–186. [CrossRef]
  • [9] Khan Y, Mishra RS. Parametric (exergy-energy) analysis of parabolic trough solar collector-driven combined partial heating supercritical CO2 cycle and organic Rankine cycle. Energy Sources A Recovery Util Environ Eff 2020. [Preprint). doi: 10.1080/15567036.2020.1788676. [CrossRef]
  • [10] Singh H, Mishra RS. Performance analysis of solar parabolic trough collectors driven combined supercritical CO2 and organic Rankine cycle. Eng Sci Technol Int J 2018;21:451–464. [CrossRef] [11] Yanbolagh DJ, Saraei A, Mazaheri H, Mehrabadi SJ. Exergoeconomic, environmental, economic, and energy-matrices (4E) analysis of three solar distillation systems equipped with condenser and different heaters. J Ther Eng 2021;7:1640–1653.[CrossRef]
  • [12] Moloney F, Almatrafi E, Goswami DY. Working fluids parametric analysis for the regenerative supercritical organic Rankine cycle for medium geothermal reservoir temperatures, Energy Proc 2017;129:599–606. [CrossRef]
  • [13] Khan Y, Mishra RS. Performance analysis of solar driven combined recompression main compressor intercooling supercritical CO2 cycle and organic Rankine cycle using low GWP fluids. Energy Built Environ 2021;3:496507. [CrossRef]
  • [14] Khan Y, Mishra RS. Performance comparison of the solar-driven supercritical organic Rankine cycle coupled with the vapour-compression refrigeration cycle. Clean Energy 2021;5:476–491. [CrossRef]
  • [15] Kose O, Koc Y, Yagli H. Performance improvement of the bottoming steam Rankine cycle (SRC) and organic Rankine cycle (ORC) systems for a triple combined system using gas turbine (GT) as topping cycle. Energy Convers Manag 2020;211:112745. [CrossRef]
  • [16] Klein SA. Engineering equation solver (EES), Academic Commercial V7.714. 2020 F-Chart Software. Available at: www.fChart.com Last Accessed Date: 26.09.2023.
  • [17] Padilla RV, Too YCS, Benito R, Stein W. Exergetic analysis of supercritical CO2 Brayton cycles integrated with solar central receivers. Appl Energy 2015;148:348–365. [CrossRef]
  • [18] Besarati SM, Goswami DY. Analysis of advanced supercritical carbon dioxide power cycles with a bottoming cycle for concentrating solar power applications. J Sol Energy Eng 2014;136:010904-1. [19] Ho CK, Iverson BD. Review of high-temperature central receiver designs for concentrating solar power. Renew Sustain Energy Rev 2014;29:835–846. [CrossRef]
  • [20] Wang X, Liu Q, Lei J, Han W, Jin H. Investigation of thermodynamic performances for two-stage recompression supercritical CO2 Brayton cycle with high temperature thermal energy storage system. Energy Convers Manag 2018;165:477–487. [CrossRef]
  • [21] Neises T, Turchi C. A Comparison of supercritical carbon dioxide power cycle configurations with an emphasis on CSP applications. Energy Proced 2014;49:1187–1196. [CrossRef]
  • [22] Cengel YA, Boles MA. Thermodynamics An Engineering Approach. 5th ed. New York: McGraw-Hill Publication; 2004. [CrossRef]
  • [23] Petela R. Exergy analysis of the solar cylindrical-parabolic cooker. Sol Energy 2005;79:221–233.
  • [24] Sukhatme SP, Nayak JK. Solar Energy: Principles of Thermal Collection and Storage, 3rd ed. New Delhi: Tata McGraw-Hill Education; 2008. p. 1–431. [CrossRef] [25] Calm JM. Refrigerant safety. ASHRAE J 1994;36:1726.
  • [26] Kulhanek M, Dostal V. Supercritical carbon dioxide cycles thermodynamic analysis and comparison I. Proc. Scco2 Power Cycle Symp, Prague, 2011.
  • [27] Song J, Li X, Ren X, Gu C. Performance analysis and parametric optimization of supercritical carbon dioxide (sCO2) cycle with bottoming Organic Rankine Cycle (ORC), Energy 2018;143:406–416. [CrossRef]
  • [28] Jaszczur M, Hassan Q. An optimisation and sizing of photovoltaic system with supercapacitor for improving self-consumption. Appl Energy 2020;279:115776. [CrossRef]
  • [29] Sharma A, Rajoria CS, Sing D, Bhamu JP, Kumar R. Numerical simula¬tion of heat transfer characteristics of taper helical and spiral tube heat exchanger. J Ther Eng 2021;7:1591–1603. [CrossRef]
  • [30] Deshmukh P W, Kasar S V, Sapkal N P. Experimental study of heat transfer in a helical coiled tube biomass fired rotary device. J Ther Eng 2022;8:772–785. [CrossRef]
  • [31] Ajimotokan H A, Ayuba I, Ibrahim H K. Thermo-economic feasibility analysis of trilateral-cycle power generators for waste heat recovery-to-power applications. J Ther Eng 2022;8:786–797. [CrossRef]