Mehmet AKAR, Sezai TAŞKIN, Serhat ŞEKER, İlyas ÇANKAYA

Detection of static eccentricity for permanent magnet synchronous motors using the coherence analysis

This paper reports on work to detect the static eccentricity faults for permanent magnet synchronous motor (PMSM) using spectral analysis methods. Measurements are carried out by collecting the stator current and voltage, torque and speed for healthy and faulty cases of the motor. Static eccentricity case is formed by changing the rotor position in the manner of sliding the shaft on a horizontal axis. As a result of the spectral analysis for the motor currents, side band effects appeared at around the fundamental frequency are determined as a most important indicator of the eccentricity. In addition to this determination, the eccentricity problem is observed from the torque and rotor speed data comparing with each others as well as current and voltage variations.

Anahtar Kelimeler:

Permanent magnet synchronous motor, eccentricity, fault diagnosis, spectral analysis

Detection of static eccentricity for permanent magnet synchronous motors using the coherence analysis

Keywords:

Permanent magnet synchronous motor, eccentricity, fault diagnosis, spectral analysis,

PDF

___

Abbreviations STFT APSD CPSD
Cross Power Spectral Density
J. Rosero, J. Cusido, A. Garcia, J. Ortega and L. Romeral, “On-line Condition Monitoring Technique for PMSM Operating with Eccentricity”, The 6thIEEE International Symposium on Diagnostics for Electric Machines, Power Electronics and Drives, IEEE SDEMPED, Cracow, Poland, pp. 111-16, 2007.
S. Seker, “Determination of Air-Gap Eccentricity in Electric Motors Using Coherence Analysis”, IEEE Power Engineering Review, Vol. 20, No. 7, pp.48-50, 2000.
S. Seker and E. Ayaz, “A reliability model for induction motor ball bearing degradation”, Electric Power Components & Systems, Vol. 31 No. 7, 2003, pp: 639-52, 2003.
E. Ayaz, S. Seker and A. Ozturk, “Continuous Wavelet Transform for Bearing Damage Detection in Electric Motors”, IEEE Melecon, May 16-19, Benalm´adena (M´alaga), Spain. pp. 1130-33, 2006.
E. Ayaz, A. Ozturk, S. Seker and B.R. Upadhyaya, “Fault detection based on continuous wavelet transform and sensor fusion in electric motors”, Compel, Vol. 28 No.2, pp. 454-70, 2009.
S. Nandi, H.A. Toliyat and X. Li, “Condition Monitoring and Fault Diagnosis of Electrical Motors - A Review”, IEEE Transactions on energy conversion, Vol. 20, No. 4, pp. 719-29, 2005.
S. Seker and E. Ayaz, “Feature extraction related to bearing damage in electric motors by wavelet analysis”, Journal of the Franklin Institute, Vol. 340, No. 2, pp. 125 –34, 2003.
S. Ozturk, Low-Cost Direct Torque Control of Permanent Magnet Synchronous Motors Using Hall-Eﬀect Sensors, M.S. Thesis, Texas A&M University, College Station, TX, 2005.
J. Rosero, J. Cusido, A. Garcia, J. Ortega and L. Romeral , “Broken Bearings and Eccentricity Fault Detection for a Permanent Magnet Synchronous Motor” (2006), The 32ndAnnual Conference of the IEEE Industrial Electronics Society, Paris - France, pp. 964-69, 2006.
M. B. Ebrahimi, J. Faiz, M. J. Roshtkhari and A. Z. Nejhad, “Static Eccentricity Fault Diagnosis in Permanent Magnet Synchronous Motor Using Time Stepping Finite Element Method”, IEEE Transactions on Magnetics, Vol. 44, No. 11, pp. 4297-4300, 2008.
W. Roux, R. G. Harley and T. G. Habetler, “Detecting Rotor Faults in Low Power Permanent Magnet Synchronous Machines ” , IEEE Transactions on Power Electronics, Vol. 22, No. 1, pp. 322-28, 2007.
M. Akar and I. Cankaya, “Diagnosis of static eccentricity fault in permanent magnet synchronous motor by on-line monitoring of motor current and voltage”, Istanbul University-Journal of Electrical and Electronics Engineering (IU-JEEE), Vol. 9, No. 2, pp. 959-967, 2009.
C. Yeh. A. Sayed and R. Povinelli, “A ReconŞgurable Motor for Experimental Emulation of Stator Winding Inter- Turn and Broken Bar Faults in Polyphase Induction Machines”, IEEE Transactions on Energy Conversion, Vol. 23, No. 4, pp. 1005-14, 2008.
C. Kral, T.G. Habetler and R.G. Harley, “Detection of Mechanical Imbalances of Induction Machines Without Spectral Analysis of Time-Domain Signals”, IEEE Transactions on Industry Applications, Vol. 40, No. 4, pp. 1101-06, 2004.
P. Vas, Parameter Estimation, Condition Monitoring, and Diagnosis of Electrical Machines, Clarendron Press, Oxford, 1993.
S. Rajagopalan, Detection of Rotor and Load Faults in Brushless DC Motors Operating under stationary and un- stationary conditions, PhD Thesis, School of Electrical and Computer Engineering, Georgia Institute of Technology, 2006.
S. Taskin, S. Seker, M. Karahan and C. Akinci, “Spectral analysis for current and temperature measurements in power cables”, Electric Power Components & Systems, Vol. 37, No. 4, pp. 415-26, 2009.
S. V. Vaseghi, Advanced Signal Processing and Digital Noise Reduction, John Wiley & Sons Inc., Chichester, England, 1996.
M. Akar, “Mechanical fault diagnosis in the permanent magnet synchronous motor with artiŞcial intelligence techniques”(in Turkish), PhD Thesis, University of Sakarya, pp.66, 2009.