EMISSIONS AND PERFORMANCE CHARACTERISTICS OF AN SI ENGINE WITH BIOGAS FUEL AT DIFFERENT CO2 RATIOS

Nowadays increasing emission regulations and environmental concerns have led to the use of alternative fuels in internal combustion engines. Biogas is an alternative fuel that can be produced with clean, green and natural resources. In this study, a single cylinder, four stroke SI engine was operated at stoichiometric conditions, 2800 rpm constant engine speed with biogas fuel at different ratios. As biogas fuel, methane (CH4) and CO2 were used during engine tests. Test results which were taken by using only gasoline were compared with the results obtained by using biogas fuel at different CO2 ratios (10%, 20%, 30% and 40% by volume). Although it was determined specific CO emissions decrease and THC emissions slightly increases with the increasing CO2 ratio, it is foreseen that the increase in THC emissions can be prevented by the use of three way catalytic converter. Although the NOx emissions increase with the use of biogas compared to gasoline, it was significantly reduced by the increased CO2 rate in the biogas fuel, the CO2's heat carrying capacity and reducing the O2 availability of the fuel. On the other hand, because of the high cost of purification process of biogas and after-treatment equipment, it is foreseen that use of biogas at high ratio of CO2 in SI engines will be advantageous in terms of NOx emissions.

Keywords:

Biogas, CO2, Methane, SI Engine, Emissions Combustion,

PDF

___

[1] European Environment Agency. (2017). Monitoring CO2 emissions from new passenger cars and vans in 2016. Report No 19/2017. Copenhagen: EEA.
[2] European Automobile Association. (2017). Economic and Market Report: key takeaways about the EU industry for 2016. ACEA
[3] European Environment Agency. (2016). Air Quality in Europe – 2016 Report. Report No 28/2016. Copenhagen: EEA.
[4] Koten, H. (2018). Performance analysis of a diesel engine within a multi-dimensional framework. Journal of Thermal Engineering (JTEN), Vol. 4, 2075-2082.
[5] Environment Pollution (Prevention and Control) Authority for the National Capital Region (EPCA). (2017). Comprehensive Action Plan for air pollution control. Report No. 70. Delhi: EPCA.
[6] Demirci, A., Koten, H., Gumus, M. (2018). The effects of small amount of hydrogen addition on performance and emissions of a direct injection compression ignition engine. Thermal Science. 22. 4-4. 10.2298/TSCI170802004D
[7] Porpatham, E., Ramesh, A., Nagalingam, B. (2013). Effect of swirl of a biogas fuelled spark ignition engine. Energy Conversion and Management, 76, 463-471.
[8] Nunes de Faria, M., Bueno, J., Ayad, S., Belchior, C. (2017). Thermodynamic simulation model for predicting the performance of spark ignition engines using biogas as fuel. Energy Conversion and Management, 149, 1096-1108.
[9] Nadaleti, C.W., Przybyla, G. (2018). Emissions and performance of a spark-ignition gas engine generator operating with hydrogen-rich syngas, methane and biogas blends for application in southern Brazillian rice industries. Energy, 154, 38-51.
[10] Karagoz, M., Kurtgoz, Y., Deniz, E. (2017) Biogas engine performance using ANN. Engineering Science and Technology, an International Journal, 20, 1563-1570.
[11] Wang, C., Kan, X., Zhou, D., Yang, W., Zhai, X. (2018) An investigation on utilization of biogas and syngas produced from biomass waste in premixed spark ignition engine. Applied Energy. 212, 210-222.
[12] Kwon, E., Song, K., Kim, M., Shin, Y., Choi, S. (2017). Performance of small spark ignition engine fueled with biogas at different compression ratio and various carbon dioxide dilution. Fuel, 196, 217-224.
[13] Nadaleti, C.W, Przybyla, G. (2018). SI engine assessment using biogas, natural gas and syngas with different content of hydrogen for application in Brazillian rice industries: Efficiency and pollutant emissions. Int J. Hyydrogen Energy, 1-14.
[14] Porpatham, E., Ramesh, A., Nagalingam, B. (2018) Experimental studies on the effects of enhancing the concentration of oxygen in the inducted charge of a biogas fuelled spark ignition engine. Energy, 142, 303-312.
[15] Yadav, S.D., Kumar, B., Thipse, S. (2013). Characteristics of biogas operated automotive SI engine to reduce exhaust emissions for green development. (No. 2013-26-0012). SAE Technical Paper.
[16] VDMA Engines and Systems. (2017). Exhaust emission legislation diesel- and gas engines. Frankfurt: VDMA.
[17] Heywood, J.B. (1988). Internal combustion engine fundamental. McGraw-Hill Education.
[18] Kline, S.J., McClintock, F.A. (1953). Describing uncertainties in single-sample experiments. Mech Eng, 75, 3-8.
[19] Pulkrabek, W. (2004). Engineering fundamentals of the internal combustion engines. Prentice Hall, New Jersey.
[20] Chuayboon, S., Prasertsan, S., Theppaya, T., Maliwan, K., Prasertsan, P. (2014). Effects of CH4, H2 and CO2 mixtures on SI Gas engine. Energy Procedia, 52, 659-665.
[21] Koten, H., Gul, M. Z. (2014). Multidimensional Modelling of Compressed Bio Gas (CBG) Engine For Ultra Low Emission. International Journal of Pure and Applied Sciences, 26(2), 41-49.
[22] Degobert, P. (1995). Automobiles and Pollution. Warrendale: SAE Society of Automotive Engineers Inc., Paris: Editions Technip.
[23] Koten, H., Yilmaz, M., Gul, M.Z. (2014). Compressed biogas-diesel dual-fuel engine optimization study for ultralow emission. Advances in Mechanical Engineering. Article ID 571063. http://dx.doi.org/10.1155/2014/571063
[24] Koten, H. (2017). Usage of biogas in a diesel engine: Compressed bio gas (CBG). LAP Lambert Academic Publishing. ISBN-13:978-3-330-07965-6.

Başlangıç: 2015
Yayıncı: YILDIZ TEKNİK ÜNİVERSİTESİ

Arşiv