Somayyeh SADRI, Seyed Yousef SEYED MOHSENİ

Investigation of Kalina Cycle for Power Generation from Heat Dissipation of Tarasht Power Plant

Anahtar Kelimeler:

efficiency enhancement; Heat Recovery; Kalina Cycle; Power Generation; Tarasht Power plant, efficiency enhancement; Heat Recovery; Kalina Cycle; Power Generation; Tarasht Power plant, efficiency enhancement, efficiency enhancement, Heat Recovery, Heat Recovery, Kalina Cycle, Power Generation, Tarasht Power plant

Investigation of Kalina Cycle for Power Generation from Heat Dissipation of Tarasht Power Plant

Fuel consumption optimization in thermal power plants is one of the essential topics in the saving energy field in the world. Then; it is necessary to review and provide solutions to increase efficiency. The present manuscript has recovered the heat dissipation from power plant stacks. The Kalina cycle was studied to use exhaust gases to generate power in the Tarasht power plant. Net power output is calculated at about 2080 kW, which increases the total power production of the plant by about 5%. According to environmental analysis, this cycle will cause less damage to the environment due to lowering the temperature of the exhaust gases in the atmosphere and not using additional fossil fuels. Therefore; it is a good solution for using heat dissipation from power plants. The only thing to consider in this solution (based on economic analysis) is the high construction cost compared to other power plant units.

Keywords:

efficiency enhancement, Heat Recovery, Kalina Cycle, Power Generation, Tarasht Power plant,

PDF

___

J.D. Maloney, R.C. Robertson, Thermodynamic Study of Ammonia-Water Heat Power Cycles, Tennessee: United States Atomic Energy Commission, 1953.
A.I. Kalina, “Combined-cycle system With Novel Bottoming Cycle,” J. Eng. Gas Turbines Power, 106, 737-742, 1984.
Y. M. El-Sayed, M. A. Tribud, “Theoretical Comparison of the Rankine and Kalina cycles,” ASME, 1, 97-102, 1985.
A.L. Kalina, H.M. Leibowitz, “Applying Kalina Technology to a Bottoming Cycle for Utility Combined Cycles,” ASME, doi:10.1115/87-GT-35.
N. S. Ganesh, T. Srinivas, “Power Augmentation in a Kalina Power Station for Medium Temperature Low Grade Heat,” J. Sol. Energy Eng., doi:10.1115/1.4023559.
F. Xu, D.Y. Goswami, “Thermodynamic Properties of Ammonia–Water Mixtures for Power-Cycle Applications,” Energy, 24, 525–536, 1999.
R. DiPippo, “Second Law Assessment of Binary Plants Generating Power from Low-temperature Geothermal Fluids,” Geothermics, 33, 565–586, 2004.
S. M. Sadrameli, D.Y. Goswami, “Optimum Operating Conditions for a Combined Power and Cooling Thermodynamic Cycle,” Appl. Energy, 84, 254–265, 2007.
Z. Danxing, C. Bin, Q. Yun, J. Hongguang, “Thermodynamic Analysis of a Novel Absorption Power/Cooling Combined-Cycle,” Appl. Energy, 83, 311-323, 2006.
H.D.M. Hettiarachchi, M. Golubovic, W.M. Worek, Y. Ikegami, “Optimum Design Criteria for an Organic Rankine Cycle Using Low-temperature Geothermal Heat Sources,” Energy, 32, 1698–1706, 2007.
M. Liu, N. Zhang, “Proposal and Analysis of a Novel Ammonia–Water Cycle for Power and Refrigeration Cogeneration,” Energy, 32, 961–970, 2007.
N. Zhang, N. Lior, “Methodology for Thermal Design of Novel Combined Refrigeration/Power Binary Fluid Systems,” Int. J. Refrig., 30, 1072–1085, 2007.
C.J. Koroneos, D.C. Rovas, “Electricity from Geothermal Energy with the Kalina Cycle an Exergy Approach,” in IEEE 2007: Int. Conf. Clean Electr. Power, Capri, Italy, pp. 423-428, 2007.
Y. Zhang, M. He, Z. Jia, X. Liu, “First Law-based Thermodynamic Analysis on Kalian Cycle,” Front. Energy Power Eng. China, 2, 145-151, 2008.
J. Wang, Y. Dai, and L. Gao, “Parametric Analysis and Optimization for a Combined Power and Refrigeration Cycle,” Appl. Energy 85, 1071–1085, 2008.
S. Ogriseck, “Integration of Kalina Cycle in a Combined Heat and Power Plant, a Case Study,” Appl. Therm. Eng., 29, 2843–2848, 2009.
P. A. Lolos, E. D. Rogdakis, “A Kalina Power Cycle Driven by Renewable Energy Sources,” Energy, 34, 457– 464, 2009.
P. Roy, M. Deilest, N. Galanis, H. Nesreddine, E. Cayer, “Thermodynmic Analysis of a Power Cycle Using a Low-temperature Source and a Binary NH3-H2O Mixture as Working Fluid,” Int. J. Therm. Sci., 49, 48-58, 2010.
F. Sun, Y. Ikegami, B. Jia, “A Study on Kalina Solar System with an Auxiliary Super Heater,” Renewable Energy, 41, 210-219, 2012.
J. Wang, Z. Yan, E. Zhou, Y. Dai, “Parametric Analysis and Optimization of Kalina Cycle Driven by Solar Energy,” Appl. Therm. Eng., 50, 408-415, 2013.
A. Modi, F. Hglind, “Performance Analysis of a Kalina Cycle for a Central Receiver Solar Thermal Power Plant with Direct Steam Generation,” Appl. Therm. Eng., 65, 201-208, 2014.
E. Wang, Z. Yu, F. Zhang, “Investigation on Efficiency Improvement of a Kalina Cycle by Sliding Condensation Pressure Method,” Energy Convers. Manage., 151, 123–135, 2017.
S. Zhang, Y. Chen, J. Wu, Z. Zhu, “Thermodynamic Analysis on a Modified Kalina Cycle with Parallel Cogeneration of Power and Refrigeration,” Energy Convers. Manage., 163, 1–12, 2018.
K. Kim, C. Han, H. KO, “Comparative Thermodynamic Analysis of Kalina and Kalina Flash Cycles for Utilizing Low-Grade Heat Sources,” Energies, doi:10.3390/en11123311.
G. Salehi, M. H. KhoshgoftarManesh, A. Alahyari, “Thermodynamic and Exergoeconomic Evaluation of Heat Recovery of Gas Refinery Steam Network Using Organic Rankine Cycle and Kalina Cycle with Different Fluids,” J. Energy Eng., doi:10.1061/(ASCE)EY.1943-7897.0000650.
Thermoflow Software (Version 23.0.1). Available: www.thermoflow.com (February 25, 2013).
H. Ajami, Design and Compilation of Maintenance and Repair Information System of Tarasht Power Plant, Tehran: Management Research and Training Institute Attached to the Ministry of Energy, 2014.
Detailed Statistics of Iran's Electricity Industry, Especially Strategic Management in 2015.
R. H. Khoshkho, H. MohagheghNejad, “Boiler Combustion Modeling in the Repowering Design of Tarasht Power Plant by Hot wind Box Method,” 31st International Electricity Conference, Tehran, pp. 1-8, 2016.
A. Modi (2015), Numerical Evaluation of the Kalina Cycle for Concentrating Solar Power Plants (PhD Thesis), DTU Mechanical Engineering, Denmark.
A. Modi, M. R. Kærn, J. G. Andreasen, F. Haglind, “Thermoeconomic Optimization of a Kalina Cycle for a Central Receiver Concentrating Solar Power Plant,” Energy Convers. Manage., 115, 276–287, 2016.
H. GAO, F. Chen, “Thermo-Economic Analysis of a Bottoming Kalina Cycle for Internal Combustion Engine Exhaust Heat Recovery,” Energies, 11, doi:10.3390/en11113044.
R. Smith, Chemical Process - Design and Integration, West Sussex: John Wiley & Sons, Ltd., 2005.
Index Values as Published by Marshall Swift Valuation Services Available: https://www.lincolninst.edu/sites/default/files/sources/events/martinez_marshall_and_swift.pdf (2018).
S. Sadri, R.H. Khoshkhoo, M. Ameri, “Optimum Exergoeconomic Modeling of Novel Hybrid Desalination System (MEDAD-RO),” Energy, 149, 74-83, 2018.
M. Babaelahi, S. Sadri, E. Rafat, “Exergy Cost Accounting and Thermoeconomic Diagnosis for Double-Solar-Gas-Turbine System (DSGT),” Energy Sources, Part A, doi: 10.1080/15567036.2019.1624892.