Md. OBAİDULLAH

14760

Particle mass and gaseous emissions from small scale modern wood stoves

Particle mass and gaseous emissions from small scale modern wood stoves

The objectives of the paper were to evaluate particle mass concentrations of PM1 (size <1 µm) and PM2.5 (size <2.5 µm), mass size distributions and CO emissions under standard laboratory conditions obtained from two commercially available modern residential wood stoves with capacity 10 kW and 20 kW. Four combustion batches with minor modification of primary air flows into the combustion chamber for each stove were conducted to evaluate the emission results. Particle mass concentrations and size distributions were measured in real time using an Electrical Low Pressure Impactor Plus (ELPI+) instrument, which measures particles with a fast response time in a wide particle size range from 6 nm to 10 µm aerodynamic diameter. Gaseous concentrations of O2 and CO2 were measured continuously using a Horiba PG-250 analyzer and CO emissions were measured using a Siemens Ultramat 6 gas analyzer. The measurement protocols of each combustion test were conducted according to the European standard EN 13229. The combustion experiments were conducted in a laboratory of a stove manufacturing plant in Belgium. The results showed that PM1 and PM2.5 concentrations of all the batches of both stoves varied from 116 to 327 mg/Nm3 and 139 to 413 mg/Nm3, respectively in the combustion cycle. Particle mass size distribution for all batches from both stoves is very similar showing a maximum in the fine mode at a particle size of around 330 nm to 500 nm. The CO emissions from all the batches varied from 447 to 1184 mg/Nm3 for the 10 kW stove and 958 to 1545 mg/Nm3 for the 20 kW stove. The experimental results of PM1, PM2.5 concentrations and CO emissions from combustion measurements could be useful for the improvement of the combustion process as well as the reduction of gaseous and particle mass emissions from these residential biomass combustion appliances.
Keywords:

particle mass concentrations, PM1, PM2.5, mass size distributions CO emissions,

PDF

___

  • [1] Obaidullah M. Particle Emissions from Small Scale Combustion Appliances. Brussel, Belgium: Vrije Universiteit Brussel (VUB); PhD thesis, November 2014.
  • [2] Obaidullah M, Bram S, Verma V, De Ruyck J. A Review on Particle Emissions from Small Scale Biomass Combustion. International Journal of Renewable Energy Research (IJRER). 2012;2:147-59.
  • [3] Obaidullah M, Bram S, De Ruyck J. Characteristics of Particle Mass Concentrations from Small Scale Biomass Combustion: A Review. VII International Conference on Energy and Environment for 21 Century. Las Villas, Cuba: Central University Marta Abreu (UCLV); 2012.
  • [4] Sippula O, Hokkinen J, Puustinen H, Yli-Pirila P, Jokiniemi J. Comparison of particle emissions from small heavy fuel oil and wood-fired boilers. Atmospheric Environment. 2009;43:4855-64.
  • [5] Obaidullah M, Bram S, De Ruyck J. Investigation on Gaseous and Particle Mass Emissions from Automatically Fired Small Scale Heating System Under Laboratory Conditions. International Journal of Renewable Energy Development. 2018;7:111-21.
  • [6] Obaidullah M, Bram S, De Ruyck J. An Overview of PM Formation Mechanisms from Residential Biomass Combustion and Instruments Using in PM Measurements. International Journal of Energy and Environment. 2018;12:41-50.
  • [7] Obernberger I, Brunner T, Barnthaler G. Fine particle emissions from Modern Austrian small scale biomass combustion plants. 15th European biomass conference and exhibition. Germany7-11 May 2007. p. 1546-57.
  • [8] Boman C, Nordin A, Bostrom D, Ohman M. Characterization of Inorganic Particulate Matter from Residential Combustion of Pelletized Biomass Fuels. Energy & Fuels. 2004;18:338-48.
  • [9] Bäfver LS, Leckner B, Tullin C, Berntsen M. Particle emissions from pellets stoves and modern and old-type wood stoves. Biomass and Bioenergy. 2011;35:3648-55. [10] Qiu G. Testing of flue gas emissions of a biomass pellet boiler and abatement of particle emissions. Renewable Energy. 2013;50:94-102.
  • [11] Stuv SA. Stuv installation instructions. 97851. Belgium 2011. p. 7.
  • [12] EN-13229. Open fires and inserts solid fuel - Requirements and test methods. French Association Standardization; June 2002.
  • [13] Obaidullah M, Sarkar M, Bram S, De Ruyck J. Evaluation of Dilution Ratio from a Partial flow Dilution Tunnel. 7th IMEC &16th Annual Paper Meet. IEB, Dhaka2-3 Jan 2015.
  • [14] Obaidullah M, Bram S, De Ruyck J. Investigation of Optimal Dilution Ratio from a Dilution Tunnel Using in Particulate Matter Measurement. International Journal of Engineering Technology and Sciences (IJETS). 2018;5:17-33.
  • [15] Kubica K, Paradiz B, Dilara P. Small combustion installation: Techniques, emissions and measure for emissions reduction. JRC Scientific and Technical Reports2007.
  • [16] Lighty JS, Veranth JM, Sarofim AF. Combustion Aerosols: Factors Governing Their Size and Composition and Implications to Human Health. Journal of the Air & Waste Management Association: Taylor & Francis; 2000. p. 1565-618.
  • [17] Nussbaumer T, Klippel N, Johansson L. Survey on measurements and emission factors on particulate matter from biomass combustion in IEA countries. Proc 16 th European Biomass Conference and Exhibition2008. p. 2-6.
  • [18] Obaidullah M, Dyakov I, Peeters L, Bram S, De Ruyck J. Comparison of particle emissions from enclosed parking garages and streets. GNEST. 2013;15:457-65.
  • [19] Bolling AK, Pagels J, Yttri KE, Barregard L, Sallsten G, Schwarze PE, et al. Health effects of residential wood smoke particles: the importance of combustion conditions and physicochemical particle properties. Particle and fibre toxicology. 2009;6:20.
  • [20] Obaidullah M, Dyakov I, Peeters L, Bram S, De Ruyck J. Investigation of Particulate Matter Pollutants in Parking Garages. In: Mastorakis N, editor. Latest advancement in Biology, Environment and Ecology. G. Enescu University, Iasi, Romania: WSEAS and NAUN Press; 2012. p. 105-10.
  • [21] Obaidullah M, Dyakov I, Peeters L, Bram S, De Ruyck J. Measurements of Particle Concentrations and Size Distributions in Three Parking Garages. International journal of energy and environment. 2012;6:508-15.
  • [22] Sippula O. Fine particle formation and emission in biomass combustion [Ph. D]. Finland: University of Eastern Finland; 2010.
  • [23] Obaidullah M, Bram S, De Ruyck J. Measurements of Particle Emissions and Size Distributions from a Modern Residential Pellet Stove under Laboratory Conditions. International Journal of Systems Applications, Engineering & Development 2019;13:1-9.
  • [24] Royal-Decree, Belgium. Regulating the minimum efficiency requirements and emission levels of pollutants heaters with solid fuels. October 2010, (available at http://environnement.wallonie.be/legis/air/air064.htm ).
  • [25] Roy MM, Corscadden KW. An experimental study of combustion and emissions of biomass briquettes in a domestic wood stove. Applied Energy. 2012;99:206-12.
  • [26] Obaidullah M, Bram S, Thomassin JD, Duquesne T, Dyakov IV, Contino F, et al. CO Emission Measurements and Performance Analysis of 10 kW and 20 kW Wood Stoves. Energy Procedia. 2014;61:2301-6.
  • [27] Pettersson Er, Boman C, Westerholm R, Bostrom D, Nordin A. Stove Performance and Emission Characteristics in Residential Wood Log and Pellet Combustion, Part 2: Wood Stove. Energy & Fuels. 2011;25:315-23.
  • [28] Schmidl C, Luisser M, Padouvas E, Lasselsberger L, Rzaca M, Ramirez-Santa Cruz C, et al. Particulate and gaseous emissions from manually and automatically fired small scale combustion systems. Atmospheric Environment. 2011;45:7443-54.
  • [29] Koyuncu T, Pinar Y. The emissions from a space-heating biomass stove. Biomass and Bioenergy. 2007;31:73-9.
  • [30] Hukkanen A, Kaivosoja T, Sippula O, Nuutinen K, Jokiniemi J, Tissari J. Reduction of gaseous and particulate emissions from small-scale wood combustion with a catalytic combustor. Atmospheric Environment. 2012.
International Journal of Energy Applications and Technologies-Cover
  • Yayın Aralığı: Yılda 2 Sayı
  • Başlangıç: 2014
  • Yayıncı: İlker ÖRS
Arşiv
Sayıdaki Diğer Makaleler

Effect of iridium spark plug gap on emission, noise, vibration of an internal combustion engine

Ziya Özçelik, Nurullah GÜLTEKİN

Particle mass and gaseous emissions from small scale modern wood stoves

Md. OBAİDULLAH

Induction assisted pasteurization of honey

Tuncay YILMAZ, Anıl BAŞARAN, Can ÇİVİ

Thermal efficiency evaluation of an organic Rankine cycle with n-pentane as working fluid

Sadık ATA, Ali KAHRAMAN, Remzi ŞAHİN

Effects of biodiesel usage on mechatronic components in automobiles with diesel engine: A review

Sinan ERDOĞAN