Co-combustion of sewage sludge and Trakya lignite: the effect of blending on combustion characteristics

Co-combustion of sewage sludge and Trakya lignite: the effect of blending on combustion characteristics

Dried municipal sewage sludge, which is an unwanted by-product of wastewater treatment, has high organic content and relatively high calorific value. These characteristics make it a potential biomass energy source. Co-combustion of coal and sludge provides advantages such as waste reduction, energy recovery and destruction of organic pollutants and pathogens. This work investigated the combustion characteristics and gas emission profiles of Trakya lignite, sewage sludge, and their blends (70 and 85 wt%). Ignition temperatures and the temperatures where maximum mass loss observed were shifted to lower temperatures with the addition of sludge to coal. The predicted and measured TG/DTG profiles of blends were compared to investigate the interactions between sewage sludge and coal during co-combustion. A synergistic effect was observed during co-combustion for both blends. The synergistic effect increased with the increase in the sludge/coal ratio in the blend.

___

  • Styszko K, Durak J, Kończak B, Głodniok M, Borgulat A (2022) The impact of sewage sludge processing on the safety of its use. Sci Rep 12:12227. https://doi.org/10.1038/s41598-022-16354-5
  • Kacprzak M, Neczaj E, Fijalkowski K, Grobelak A, Grosser A, Worwag M, Rorat A, Brattebo H, Almas A, Singh BR (2017) Sewage sludge disposal strategies for sustainable development. Environ Res 156:39-46. https://doi.org/https://doi.org/10.1016/j.envres.2017.03.010
  • Fijalkowski K, Rorat A, Grobelak A, Kacprzak MJ (2017) The presence of contaminations in sewage sludge - The current situation. J Environ Manage 203:1126-1136. https://doi.org/https://doi.org/10.1016/j.jenvman.2017.05.068
  • Kwarciak-Kozłowska A, 15 - Co-composting of sewage sludge and wetland plant material from a constructed wetland treating domestic wastewater, in: M.N.V. Prasad, P.J. de Campos Favas, M. Vithanage, S.V. Mohan (Eds.) Industrial and Municipal Sludge, Butterworth-Heinemann, 2019, pp. 337-360, 2019.
  • Schnell M, Horst T, Quicker P (2020) Thermal treatment of sewage sludge in Germany: A review. J Environ Manage 263.https://doi.org/https://doi.org/10.1016/j.jenvman.2020.110367
  • Li H, Jin C, Zhang ZY, O'Hara I, Mundree S (2017) Environmental and economic life cycle assessment of energy recovery from sewage sludge through different anaerobic digestion pathways. Energy 126:649-657. https://doi.org/https://doi.org/10.1016/j.energy.2017.03.068
  • Zaker A, Chen Z, Wang XL, Zhang Q (2019) Microwave-assisted pyrolysis of sewage sludge: A review. Fuel Process Technol 187:84-104. https://doi.org/10.1016/j.fuproc.2018.12.011
  • Gil-Lalaguna N, Sanchez JL, Murillo MB, Atienza-Martinez M, Gea G (2014) Energetic assessment of air-steam gasification of sewage sludge and of the integration of sewage sludge pyrolysis and air-steam gasification of char. Energy 76: 652-662. https://doi.org/10.1016/j.energy.2014.08.061
  • IEA, 2021, Global Energy Review 2021, IEA, Paris. https://www.iea.org/reports/global-energy-review-2021
  • Niu SB, Chen MQ, Li Y, Xue F (2016) Evaluation on the oxy-fuel combustion behavior of dried sewage sludge. Fuel 178:129-138. https://doi.org/10.1016/j.fuel.2016.03.053
  • Firtina-Ertis I, Ayvaz-Cavdaroglu N, Coban A (2021) An optimization-based analysis of waste to energy options for different income level countries. Int J Energy Res 45:10794-10807. https://doi.org/10.1002/er.6562
  • Magdziarz A, Werle S (2014) Analysis of the combustion and pyrolysis of dried sewage sludge by TGA and MS. Waste Manage 34:174-179. https://doi.org/10.1016/j.wasman.2013.10.033
  • Otero M, Gomez X, Garcia AI, Moran A (2008) Non-isothermal thermogravimetric analysis of the combustion of two different carbonaceous materials - Coal and sewage sludge. J Therm Anal Calorim 93:619-626. https://doi.org/10.1007/s10973-007-8415-y
  • Li FZ, Zhang W (2011) Combustion of Sewage Sludge as Alternative Fuel for Cement Industry. J Wuhan Univ Technol Mater 26:556-560. https://doi.org/10.1007/s11595-011-0267-4
  • Wang CX, Wang XH, Jiang XD, Li FY, Lei YY, Lin QZ (2019) The thermal behavior and kinetics of co-combustion between sewage sludge and wheat straw. Fuel Process Technol 189:1-14. https://doi.org/10.1016/j.fuproc.2019.02.024
  • Li JP, Hu JQ, Wang T, Gan JH, Xie JP, Shui YH, Liu JX, Xue YJ (2019) Thermogravimetric analysis of the co-combustion of residual petrochemical sludge and municipal sewage sludge. Thermochim Acta 673:60-67. https://doi.org/10.1016/j.tca.2019.01.014
  • Garcia R, Pizarro C, Lavin AG, Bueno JL (2013) Biomass proximate analysis using thermogravimetry. Bioresour Technol 139:1-4. https://doi.org/10.1016/j.biortech.2013.03.197
  • D240 Standard test method for heat of combustion of liquid hydrocarbon fuels by bomb calorimeter, (2017),ASTM International, West Conshohocken, PA, USA
  • E871-82 Standard test method for moisture analysis of particulate wood fuels, (2013),ASTM International, West Conshohocken, PA, USA
  • Lu JJ, Chen WH (2015) Investigation on the ignition and burnout temperatures of bamboo and sugarcane bagasse by thermogravimetric analysis. Appl Energy 160:49-57. https://doi.org/10.1016/j.apenergy.2015.09.026
  • Xu WY, Wu D (2015) Comprehensive utilization of the pyrolysis products from sewage sludge. Environ Technol 36:1731-1744. https://doi.org/10.1080/09593330.2015.1008584
  • Guo FH, He Y, Hassanpour A, Gardy J, Zhong ZP (2020) Thermogravimetric analysis on the co-combustion of biomass pellets with lignite and bituminous coal. Energy 197. https://doi.org/10.1016/j.energy.2020.117147
  • Guo Y, Wu JJ, Jia WK, Guo FH, Qiu GF, Wang RM, Zhang YX, Dai BQ (2021) Evaluation of the Thermal Behavior, Synergistic Catalysis, and Pollutant Emissions during the Co-Combustion of Sewage Sludge and Coal Gasification Fine Slag Residual Carbon. Catalysts 11. https://doi.org/10.3390/catal11101142
  • Tong W, Liu Q, Ran G, Liu L, Ren S, Chen L, Jiang L (2019) Experiment and expectation: Co-combustion behavior of anthracite and biomass char. Bioresour Technol 280:412-420. https://doi.org/https://doi.org/10.1016/j.biortech.2019.02.055
  • Selcuk N, Yuzbasi NS (2011) Combustion behaviour of Turkish lignite in O2/N2 and O2/CO2 mixtures by using TGA–FTIR. J Anal Appl Pyrolysis 90:133-139. https://doi.org/https://doi.org/10.1016/j.jaap.2010.11.003