Mehmet ŞİMŞEK, Haydar KÜÇÜK, Adnan MİDİLLİ

Experimental Investigation and Mathematical Modeling of Microwave Thin Layer Drying Behaviour of Apricot, Kiwi and Mint Leaves

In this study, experimental investigation and mathematical modeling of microwave drying behavior of some vegetables and fruits such as apricot, kiwi and mint leaves are performed. In this regard, a microwave oven is used for experiments and 23 thin layer drying curve equation in the literature are evaluated for mathematical modeling of drying behavior of those products. For this purpose, mass loss and drying time are measured depending on six different microwave powers (100W, 300W, 450W, 600W, 700W, and 800W) and dimensionless mass ratio, moisture content, drying rate and mass shrinkage ratio are estimated and variation of colors are observed. For comparison of equations obtained from modeling, 14 different evaluation criteria are used and the best five drying model are determined. Consequently, it is determined that the most suitable microwave powers were 300W, 600W, 700W and the best drying models are Modified Page, Midilli-Kucuk and Midilli-Kucuk for apricot, kiwi and mint leaves, respectively. Also, it is observed that when the microwave power increases, drying time significantly decreases. However, it is seen that microwave drying method is suitable for drying of kiwi and mint leaves but not suitable for drying of apricot especially at high microwave powers.

Anahtar Kelimeler:

Thin layer drying, Microwave drying, Apricot, Kiwi, Mint leaves, Mathematical modeling

Experimental Investigation and Mathematical Modeling of Microwave Thin Layer Drying Behaviour of Apricot, Kiwi and Mint Leaves

Keywords:

Thin layer drying, Microwave drying, Apricot, Kiwi, Mint leaves, Mathematical modeling,

PDF

___

Agbede, O.O., Oke, E.O, Akinfenwa, S.I., Wahab, K.T., Ogundipe, S., Aworanti, O.A., Arinkoola, A.O., Agarry, S.E., Ogunleye, O.O, Osuolale, F.N., Babatunde, K.A. (2020). Thin layer drying of green microalgae (Chlorella sp.) paste biomass: Drying characteristics, energy requirement and mathematical modeling. Bioresource Technology Reports, 11, 100467. https://doi.org/10.1016/j.biteb.2020.100467
Al-Harahsheh, M., Al-Muhtaseb, A.H., Magee, T.R.A. (2009). Microwave drying kinetics of tomato pomace: effect of osmotic dehydration. Chemical Engineering and Processing: Process Intensification, 48(1), 524–531. https://doi.org/10.1016/j.cep.2008.06.010
Alibaş, İ. (2012). Microwave drying of grapevine (Vitis vinifera L.) leaves and determination of some quality parameters. Journal of Agricultural Sciences, 18, 43-53. In Turkish
Argyropoulos, D., Heindl, A., Müller, J. (2011). Assessment of convection, hot-air combined with microwave-vacuum and freeze-drying methods for mushrooms with regard to product quality. International Journal of Food Science and Technology, 46(2), 333–342. https://doi.org/10.1111/j.1365-2621.2010.02500.x
Balbay, A. ve Şahin, Ö. (2012). Microwave drying kinetics of a thin-layer liquorice root. Drying Technology, 30(8), 859–864. https://doi.org/10.1080/07373937.2012.670682
Baltacıoğlu, C., Uslu, N., Özcan, M.M. (2015). Optimization of microwave and air drying conditions of quince (Cydonia oblonga, Miller) using response surface methodology. Italian Journal of Food Science, 27, 1-7. 10.14674/1120-1770/IJFS.V85
Bingol, G., Pan, Z., Roberts, J.S., Devres, Y.O., Balaban, M.O. (2008). Mathematical modeling of microwave-assisted convective heating and drying of grapes. International Journal of Agricultural and Biological Engineering, 1(2), 46–54. 10.3965/j.issn.1934-6344.2008.02.046-054
Chahbani, A., Fakhfakh, N., Balti, M.A., Mabrouk, M., El-Hatmid, H., Zouari, N., Kechaou, N. (2018). Microwave drying effects on drying kinetics, bioactive compounds and antioxidant activity of green peas (Pisum sativum L.). Food Bioscience, 25, 32-38. https://doi.org/10.1016/j.fbio.2018.07.004
Cuccurullo, G., Metallo, A., Corona, O., Cinquanta, L. (2019). Comparing different processing methods in apple slice drying. Part 1. Performance of microwave, hot air and hybrid methods at constant temperatures. Biosystems Engineering, 188, 331-344. https://doi.org/10.1016/j.biosystemseng.2019.10.021
Dadali, G., Demirhan, E., Özbek, B. (2007). Microwave heat treatment of spinach: drying kinetics and effective moisture diffusivity. Drying Technology, 25(10), 1703–1712. https://doi.org/10.1080/07373930701590954
Dadali, G., Özbek, B. (2008). Microwave heat treatment of leek: Drying kinetic and effective moisture diffusivity. International Journal of Food Science and Technology, 43(8), 1443–1451. https://doi.org/10.1111/j.1365-2621.2007.01688.x
Darvishi, H. (2012). Energy consumption and mathematical modeling of microwave drying of potato slices. Agricultural Engineering International: CIGR Journal, 4(1), 94–102.
Darvishi, H., Azadbakht, M., Rezaeias, A., Farhang, A. (2013). Drying characteristics of sardine fish dried with microwave heating. Journal of the Saudi Society of Agricultural Sciences, 12(2), 121–127. https://doi.org/10.1016/j.jssas.2012.09.002
Demirhan, E., Özbek, B. (2010a). Microwave-drying characteristics of basil. Journal of Food Processing and Preservation, 34(3), 476–494. https://doi.org/10.1111/j.1745-4549.2008.00352.x
Demirhan, E., Özbek, B. (2010b). Drying kinetics and effective moisture diffusivity of purslane undergoing microwave heat treatment. Korean Journal of Chemical Engineering, 27(5), 1377–1383. https://doi.org/10.1007/s11814-010-0251-2
Demirhan, E., Ozbek, B. (2011). Thin-layer drying characterıstics and modeling of celery leaves undergoing microwave treatment. Chemical Engineering Communications, 198(7), 957–975. https://doi.org/10.1080/00986445.2011.545298
Doğru, M., Midilli, A., Howarth C.R. (2002). Gasification of sewage sludge using a throated downdraft gasifier and uncertainty analysis. Fuel Processing Technology 75, 55-82. https://doi.org/10.1016/S0378-3820(01)00234-X
Drouzas, A.E., Tsami, E. and Saravacos, G.D. (1999). Microwave-vacuum drying of model fruit gels. Journal of Food Engineering, 39(2), 117–122. https://doi.org/10.1016/S0260-8774(98)00133-2
Duan, Z., Zhang, M., Hu, Q., Sun, J. (2005). Characteristics of microwave drying of bighead carp. Drying Technology, 23(3), 637–643.
Du, J., Gao, L., Yang, Y., Guo, S., Chen, J., Omran, M., Chen, G. (2020). Modeling and kinetics study of microwave heat drying of low grade manganese ore. Advanced Powder Technology, 31, 2901-2911. https://doi.org/10.1016/j.apt.2020.05.013
Eştürk, O., Soysal, Y. (2010). Drying properties and quality parameters of dill dried with intermittent and continuous microwave-convective air treatments, Journal of Agricultural Sciences, 16, 26–36. https://doi.org/10.1501/Tarimbil_0000001118
Esturk, O. (2012). Intermittent and continuous microwave-convective air-drying characteristics of sage (Salvia officinalis) leaves. Food and Bioprocess Technology, 5(5), 1664–1673. https://doi.org/10.1007/s11947-010-0462-x
Evin, D. (2011). Investigation on the drying kinetics of sliced and whole rosehips at different moisture contents under microwave treatment. Scientific Research and Esssays, 6(11), 2337-2347. https://doi.org/10.5897/SRE11.082
Fu, B.A., Chen, M.Q, Song, J.J. (2017). Investigation on the microwave drying kinetics and pumping phenomenon of lignite spheres. Applied Thermal Engineering, 124, 371-380. https://doi.org/10.1016/j.applthermaleng.2017.06.034
Ganesapillai, M., Regupathi, I., Murugesan, T. (2008). An empirical model for the estimation of moisture ratio during microwave drying of plaster of paris. Drying Technology, 26(7), 963–978. https://doi.org/10.1080/07373930802142978
Ganesapillai, M., Miranda, L.R., Regupathi, I. (2009). Mathematical modeling in drying and determination of effective moisture diffusivity of caso41/2h2o during microwave drying. In Proceedings of First International Conference on Nanostructured Materials and Nanocomposites, April 6–8, 373–381, Kottayam, India.
Ganesapillai, M., Regupathi, I., Murugesan, T. (2011). Modeling of thin layer drying of banana (Nendran Spp) under microwave, convective and combined microwave-convective processes. Chemical Product and Process Modeling, 6((1)10), 1–29. https://doi.org/10.2202/1934-2659.1479
Gunasekaran, S. (1999). Pulsed microwave-vacuum drying of food materials. Drying Technology, 17, 395-412. https://doi.org/10.1080/07373939908917542
Hemis, M., Singh, C.B., and Jayas, D. S. (2011). Microwave-sssisted thin layer drying of wheat. Drying Technology, 29, 1240–1247. https://doi.org/10.1080/07373937.2011.584999
Karaaslan, S. (2008). The Experiments on Vegetables and Industrial Plant Drying by Microwave Energy. Ph.D. thesis, Çukurova University, Adana, Turkey, [in Turkish].
Karaaslan, S.N., Tuncer, İ.K. (2008). Development of a drying model for combined microwave-fan assisted convection drying of spinach. Biosystems Enginering, 100, 44 – 52. https://doi.org/10.1016/j.biosystemseng.2007.12.012
Karaaslan, S., Tunçer, İ.K. (2011). Development of drying model and determination of color characteristics for combined microwave-fan assisted convection drying of green tea. The Philippine Agricultural Scientist, 94(2), 161–170.
Kucuk, H., Midilli, A., Kilic, A., Dincer, I. (2014). A review on thin-layer drying-curve equations, Drying Technology, 32 (7), 757-773. https://doi.org/10.1080/07373937.2013.873047
Lekachaiworakul, P., Dangvilailux, P., Rattanamechaiskul, C. (2017). Effects of hot air and microwave drying on kinetic rate and mechanical property of oil palm veneer. Energy Procedia, 138, 1093-1098. https://doi.org/10.1016/j.egypro.2017.10.124
Li, H., Lin, B,, Hong, Y., Liu, T., Huang, Z., Wang, R., Wang, Z. (2018). Assessing the moisture migration during microwave drying of coal using low-field nuclear magnetic resonance. Drying Technology, 36(5), 567–577. https://doi.org/10.1080/07373937.2017.1349136
Lopez-Vidana, E.C., Figueroa,I.P., Cortes, F.B., Rojano, B.A., Ocaana, A.N. (2017). Effect of temperature on antioxidant capacity during drying process of mortiño (Vaccinium meridionale Swartz). International Journal of Food Properties, 20(2), 294–305. https://doi.org/10.1080/10942912.2016.1155601.
Maskan, M. (2001). Drying, shrinkage and dehydration characteristics of kiwifruits during hot air and microwave drying. Journal of Food Engineering, 48, 177-182. https://doi.org/10.1016/S0260-8774(00)00155-2
McMinn, W.A.M., McLoughlin, C.M., Magee, T.R.A. (2005). Thin-layer modeling of microwave, microwave-convective, and microwave-vacuum drying of pharmaceutical powders. Drying Technology, 23(3), 513–532. https://doi.org/10.1081/DRT-200054126
McMinn, W.A.M. (2006). Thin-layer modeling of the convective, microwave, microwave-convective and microwave-vacuum drying of lactose powder. Journal of Food Engineering, 72(2), 113–123. https://doi.org/10.1016/j.jfoodeng.2004.11.025
Murthy, T.P.K., Manohar, B. (2012). Microwave drying of mango ginger (Curcuma amada Roxb): Prediction of drying kinetics by mathematical modelling and artificial neural network. International Journal of Food Science and Technology, 47(6), 1229–1236. https://doi.org/10.1111/j.1365-2621.2012.02963.x
Midilli A., Olgun H., Ayhan T. (1999). Experimental studies on mushroom and pollen drying. International Journal of Energy Research, 23, 1143-1152. https://doi.org/10.1002/(SICI)1099-114X(19991025)23:13<1143::AID-ER544>3.0.CO;2-3
Motevali, A., Minaei, S., Banakar, A., Ghobadian, B., Darvishi, H. (2016). Energy analyses and drying kinetics of chamomile leaves in microwave-convective dryer. Journal of the Saudi Society of Agricultural Sciences, 15, 179-187. https://doi.org/10.1016/j.jssas.2014.11.003
Nair, G.R., Liplap, P., Gariepy, Y., Raghavan, G.S.V. (2011). Microwave drying of flax fibre at controlled temperatures. Journal of Agricultural Science and Technology B, 1(8b), 1103–1115. 10.1504/IJPTI.2012.050982
Nindo, C.I., Sun, T., Wang, S.W., Tang, J., Powers, J.R. (2003). Evaluation of drying technologies for retention of physical quality and antioxidants in asparagus (Asparagus officinalis L.). Lebensmittel Wissenschaft und Technologie, 36, 507-515. https://doi.org/10.1016/S0023-6438(03)00046-X
Özbek, B., Dadalı, G. (2007). Thin layer drying characteristics and modeling of mint leaves undergoing microwave treatment. Journal of Food Engineering, 83(4), 541-549. https://doi.org/10.1016/j.jfoodeng.2007.04.004
Özkan, İ., Akbudak, A. and Akbudak, N. (2007). Microwave drying characteristics of spinach. Journal of Food Engineering, 78(2), 577–583. DOI: 10.1016/j.jfoodeng.2005.10.026.
Pillai, M.G., Regupathi, I., Miranda, L.R.,Murugesan, T. (2010). Moisture diffusivity and energy consumption during microwave drying of plaster of paris. Chemical Product and Process Modeling, 5(1), 4, 1–23. http://www.bepress.com/cppm/vol5/iss1/4.
Qiu, L., Zhang, M., Tang, J., Adhikari, B., Cao, P. (2019). Innovative technologies for producing and preserving intermediate moisture foods: A review. Food Research International, 116, 90-102. https://doi.org/10.1016/j.foodres.2018.12.055.
Ranjbaran, M., Zare, D. (2012). A new approach for modeling of hot air-microwave thin layer drying of soybean. Electronic Journal of Polish Agricultural Universities, 15(3), 795–810.
Reddy, L. (2006). Drying Characteristics of Saskatoon Berries under Microwave and Combined Microwave-convection Heating. M.Sc. thesis, University of Saskatchewan, Saskatoon, Canada.
Sarimeseli, A. (2011). Microwave drying characteristics of coriander (Coriandrum sativum L.) leaves. Energy Conversion and Management, 52(2), 1449–1453. https://doi.org/10.1016/j.enconman.2010.10.007
Shah, S., Joshi, M. (2010). Modeling microwave drying kinetics of sugarcane bagasse. International Journal of Electronics Engineering, 2(1), 159–163.
Sharifian, F., Motlagh, A.M., Nikbakht, A.M. (2012). Pulsed microwave drying kinetics of fig fruit (Ficus carica L.). Australian Journal of Crop Science, 6(10), 1441–1447.
Shen, L., Zhu, Y., Liu, C., Wang, L., Liu, H., Kamruzzaman, M., Liu, C., Zhang, Y., Zheng, X. (2020). Modelling of moving drying process and analysis of drying characteristics for germinated brown rice under continuous microwave drying. Biosystems Engineering, 195, 6 4-8 8. https://doi.org/10.1016/j.biosystemseng.2020.05.002
Silva, F.A., Marsaioli Jr.A., Maximo,G.J., Silva, M.A.A.P., And Gonçalves, L.A.G. (2006). Microwave assisted drying of macadamia nuts. Journal of Food Engineering, (77), 550-558.
Sledz, M., Witrowa-Rajchert, D. (2012). Kinetics of microwave-convective drying of some herbs. International Conference of Agricultural Engineering, July 8–12, Valencia, Spain.
Soysal, Y., Öztekin, S., Eren, Ö. (2006). Microwave drying of parsley: Modelling, kinetics, and energy aspects. Biosystems Engineering, 93(4), 403–413. https://doi.org/10.1016/j.biosystemseng.2006.01.017
Szadzinska, J., Kowalski, S.J., Stasiak, M. (2016). Microwave and ultrasound enhancement of convective drying of strawberries: Experimental and modeling efficiency. International Journal of Heat and Mass Transfer, 103, 1065-1074. https://doi.org/10.1016/j.ijheatmasstransfer.2016.08.001
Şimşek, M. (2018). Experimental investigation and mathematical modeling of microwave drying behavior of some vegetables and fruits. M.Sc. Thesis, Recep Tayyip Erdogan University, Rize, Turkey.
Thiagarajan, I.V. (2008). Combined Microwave-convection Drying and Textural Characteristics of Beef Jerky. M.Sc. thesis, University of Saskatchewan, Saskatoon, Canada.
Venkatesh, M.S., Raghavan, G.S.V. (2004). An overview of microwave processing and dielectric properties of agri-food materials. Biosystem Engineering, 88(1), 1-18. https://doi.org/10.1016/j.biosystemseng.2004.01.007
Wang, S., Tang, J., Johnson, J.A., Mitcham, E. J., Hansen, D., Hallman, G., Drake, S.R. and Wang, Y. (2003). Dielectric properties of fruits and ınsect pests as related to radio frequency and microwave treatments. Biosystem Engineering, 85 (2), 201–212. https://doi.org/10.1016/S1537-5110(03)00042-4
Wang, Z.-F., Fang, S.-Z., Hu, X.-S. (2009). Effective diffusivities and energy consumption of whole fruit Chinese jujube (Zizyphus jujuba Miller) in microwave drying. Drying Technology, 27(10), 1097–1104. https://doi.org/10.1080/07373930903221200
Won, K.H., Jonathan, C. and Kim, H.E. (2004). Hydroxyapatite and gelatin composite foams processed via novel freeze-drying and crosslinking for use as temporary hard tissue scaffolds. Journal of Biocemical Resaerch, 72, 136–45. https://doi.org/10.1002/jbm.a.30168
Xu, W., Cao, X., Zhu, G., Xia, Z., Wang, D. (2020). Effect of temperature difference on the aroma and quality of carrots processed through microwave drying combined with hot air drying. Food and Bioproducts Processing, 120, 58-68. https://doi.org/10.1016/j.fbp.2019.12.006
Yurtsever, S. (2005). Mathematical modeling and evaluation of microwave drying kinetics of mint (Mentha spicatta L.). Journal of Applied Sciences, 5(7), 1266–1274. 10.3923/jas.2005.1266.1274
Zarein, M., Samadib, S.H., Ghobadian, B. (2015). Investigation of microwave dryer effect on energy efficiency during drying of apple slices. Journal of the Saudi Society of Agricultural Sciences, 14(1), 41-47. https://doi.org/10.1016/j.jssas.2013.06.002