HAMSİ'NİN LTHV (DÜŞÜK SICAKLIK VE YÜKSEK HIZ) KURUTMA KARAKTERİSTİKLERİ VE MATEMATİKSEL MODELLENMESİ (Engraulis encrasicolus)

Bu çalışmanın temel amacı, Hamsinin (Engraulis encrasicolus) LTHV kurutma özelliklerini deneysel olarak araştırmaktır. Bu amaçla, 100 g Hamsi örnekleri bağıl nemin % 38 ± 5 olduğu, 4, 10, 15 ve 20 °C sıcaklıklarda kurutuldu. Deneyler sırasında kütle kaybı, sıcaklık, kuruma hızı ve bağıl nemi değerleri belirlenmiştir. Hamsi filetolarının ağırlığı, 4° C'de 25 saatte, 100 g dan 47,6 g 'a, 10°C 23 saatte 46,7g’a,  15°C 20 saatte 45,3 g’a,  20°C’de 13 saatte  44,67 g a düşmüştür. Bu bağlamda, gözlemlenen kurutma deney verileri üzerine yirmi üç ortak matematiksel model uygulanmıştır. Sonuç olarak, Hamsinin her LTHV kurutma sıcaklığı için en uygun matematiksel modeller belirlenmiştir. Bu bağlamda, Logaritmik (Asimptotik), Midilli-Küçük, Demir ve diğerleri, Balbay ve Şahin, her LTHV kurutma sıcaklığı için 4, 10, 15 ve 20oC'de en uygun matematiksel modeller olduğu belirlenmiştir. Sonuç olarak, hamsinin ince tabaka LTHV kurutma karakteristiğini en iyi temsil edecek en uygun modeller ortaya konmuştur.

LTHV (LOW TEMPERATURE AND HIGH VELOCITY) DRYING CHARACTERISTICS AND MATHEMATICAL MODELING OF ANCHOVY (Engraulis encrasicolus)

The main target of this study is experimentally investigating the characteristics of LTHV drying of anchovy (Engraulis encrasicolus). For these purposes, 100 g of anchovy samples were dried at different temperatures of 4, 10, 15 and 20oC in ranges of 38±5 percent of relative humidity. During the experiments, mass loss, temperature, drying air velocity and relative humidity were investigated. The weight of raw Anchovy fillets were decrease from 100 g to  47,6 g at 4°C for 25 h, 46,7g at 10°C for 23 h,  45,3 g at 15°C for 20 h and 44,67 g at 20°C for 13 h.  In this context, Twenty-three common mathematical models were applied on the observed experimental data of drying. As result, the most suitable mathematical models were determined for the each LTHV drying temperature of Anchovy. In this regard, Logarithmic (Asymptotic), Midilli-Kucuk, Demir et al., Balbay and Şahin were determined the most suitable mathematical models for each LTHV drying temperature at 4, 10, 15 and 20oC. Consequently, the best single layer drying curve equations were selected as the most suitable models for thin layer LTHV drying of anchovy.

___

  • Abid, M., Gibert R., Laguerie, C. (1990). An experimental and theoretical analysis of the mechanisms of heat and mass transfer during the drying of corn grains in a fluidized bed. International Chemical Engineering, 30 ( 4) 632-642. AOAC. Official methods of analysis of AOAC International (16th ed), V II, Arlington, VA, USA: 1995; 938–940. Chairi, H. and Rebordinos, L. (2014). A Rapid Method for Differentiating Four Species of the Engraulidae (Anchovy) Family. J. Agric. Food Chem., 62, 2803−2808. Chin, S.K.; Law, C.L., Supramaniam, C.V.S.; Cheng, P.G. (2008). Mujumdar, A.S. Convective drying of Ganoderma tsugae Murrill and effect of temperature on basidiospores. Drying Technology, 26(12), 1524–1533. Copley, M.T., and Van Arsdel, W.B. (1964). Food dehydration, Vol II-Products and technology. AVI Publications Company, West-port. Cruess, W.V. (1958).Commercial fruit and vegetable products. McGraw-Hill, New York. Dincer I, (1996). Sun drying of sultana grapes, Drying Technology, 14:1827-1838. Dincer I. (1998). Moisture loss from wood products during drying-Part I: Moisture diffusivities and moisture transfer coefficients, Energy Sources. 20:67-75. Dongbang, W. and Matthujak, A. 2013. Anchovy Drying Using Infrared Radiation. American Journal of Applied Sciences, 10 (4): 353-360. Erturk, M.A , Oktay, Z.B , Coskun, C.B , Kilic, G.A.C , Dasdemir, A.D, A. (2015). New approach to calculation of energy demand and amount of emission according to different indoor temperature. International Journal of Global Warming, 7(3), 395-408. Hall, C.W. (1980). Drying and storage of agricultural crops. AVI Publiching Company, Inc., Westport. KEEY, R.B. (1992). Drying of loose and particulate materials. Hemisphere Publishing Corporation, USA. Kilic A., Kucuk H., Midilli A. (2014). Environmental Friendly Food Smoking Technologies, in Progress in Sustainable Energy Technologies Vol II. edted by Dincer et al. (Springer press). ISBN 978-3-319-07976-9. Kilic, A. (2017). Mathematical Modeling of Low Temperature High Velocity (LTHV) Drying in Foods. Journal of Food Process Engineering. In Press. DOI:10.1111/jfpe.12378. Kilic, A. 2009. LowTemperature and High Velocity (LTHV) application in drying: characteristics and effects on the fish quality, Journal of Food Engineering, 91, 173–182. Kilic, A., Midilli, A. and Dincer, I. (2010). A strategicprogram to reduce greenhouse gases emissions produced from food industry, Chapter: 10, pp. 197-210 in Global Warming: Engineering Solutions. Green Energy and Technology Series;Edited by Dincer, et al. (Springer press). Kilic, A., Midilli, A. and I. Dincer, A. (2010). A novel fish-drying technique for better environment, quality and sustainability. Internatıonal Journal of Global Warmıng. 2, 3, pp: 262-278. Kilic, A., Oztan, A. (2013). Effect of Ascorbic Acid Utilization on Cold Smoked Fish Quality (Oncorhynchus mykiss) during Process and Storage. Food Science and Technology Research, 19, 5, pp 823-831. Kosuke, N., Li, Y., Jin, Z., Fukumuro, M., and O, Y., Akaishi A. (2006). Low-temperature desiccant-based food drying system with airflow and temperature control. Journal of Food Engineering, 75, 71–77. Kucuk, H., Midilli, A., Kilic, A. and Dincer, I. (2014). A Review on Thin-Layer Drying-Curve Equations. Drying Technology, 32 (7), 757-773. Midilli, A. (2001). Determination of pistachio drying behavior and conditions in a solar drying system. International J Energy Research, 25, 715-725. Midilli, A., and Kucuk, H. (2003). Mathematical modeling of thin layer drying of pistachio by using solar energy. Energy Conversion & Management, 44, 1111-1122. Midilli, A., Kucuk, H. and Yapar, Z., A (2002). New model for single-layer drying. Drying Technology, 20 (7), 1503-1513. Midilli, A., Olgun, H. and Ayhan, T. (1999). Experimental studies on mushroom and pollen drying. nternational Journal of Energy Research, 23 (13), 1143-1152. Midilli, A., Olgun, H. and Rzayev, P. (2000). Drying and conservation conditions of pollen. Journal of the Science of Food and Agriculture, 80 (13), 1973-1980. Moraes, K. De and Pinto, L. A. De A. (2013). Drying Kinetics, Biochemical and Functional Properties of Products in Convective Drying of Anchovy (Engraulis anchoita) Fillets. International Journal of Food Engineering, 9(4): 341–351. Olgun H and Kose S. (1999).Solar drying of rainbow trout, Int J Energy Research, 23:941-948. Van Loey, A.M., Smout, C., Indrawati, Hendrick, M.E. (2005). Kinetic data for biochemical and microbiological processes during thermal processing. In M.A. Rao, S.S.H. Rizvi, and A.K. Datta, (Eds.), Engineering Properties of Foods, CRC Taylor & Francis, 3rd ed., chap 13, pp. 611–643,
Gıda-Cover
  • ISSN: 1300-3070
  • Yayın Aralığı: Yılda 6 Sayı
  • Başlangıç: 1976
  • Yayıncı: Prof. Dr. İbrahim ÇAKIR
Sayıdaki Diğer Makaleler

THE EFFECT OF DRIED MUSHROOM (AGARICUS BISPORUS) ADDITION ON MICROBIOLOGICAL QUALITY AND BIOGENIC AMINE CONTENTS IN SUCUK PRODUCTION

Hüseyin GENÇCELEP, Ömer ZORBA

THE EFFECTS OF DIFFERENT MODIFIED STARCHES ON SOME PHYSICAL AND TEXTURE PROPERTIES OF MEAT EMULSION

Hüseyin GENÇCELEP, Furkan Türker SARİCAOĞLU, Berrin AĞAR, Münir ANİL

SOĞAN DİLİMLERİNİN KURUTULMASI ESNASINDA RENK DEĞİŞİMİNE ETKİ EDEN FAKTÖRLERİN YANIT YÜZEY YÖNTEMİ İLE BELİRLENMESİ

Hande Demir, Özge Süfer, Seda Sezer

SOMATİK HÜCRELER VE ENDOJEN ENZİMLERİNİN SÜT TEKNOLOJİSİNDEKİ ÖNEMİ

Elif ÖZER, Ayşe Sibel AKALIN, Harun KESENKAŞ, Gülfem ÜNAL

BİYOBAZLI NANOKOMPOZİTLER VE GIDA AMBALAJLAMADAKİ UYGULAMALARI

Ece SÖĞÜT, Atif Can SEYDİM

LAKTİK ASİT BAKTERİLERİNİN AFLATOKSİN B1 BAĞLAYICI VE ANTİKANSEROJEN ÖZELLİKLERİ

Şebnem Kurhan, İbrahim ÇAKIR

GELENEKSEL TURŞULARDAN İZOLE EDİLEN LAKTİK ASİT BAKTERİLERİNİN TEKNOLOJİK ÖZELLİKLERİ

FİLİZ ÖZÇELİK, Mehmet TOKATLI, Simel BAĞDER ELMACI, Nurdan ARSLANKOZ İŞLEYEN

SUCUK ÜRETİMİNDE KURUTULMUŞ MANTAR (AGARICUS BISPORUS) İLAVESİNİN MİKROBİYOLOJİK KALİTE VE BİYOJENİK AMİN İÇERİĞİ ÜZERİNE ETKİLERİ

Hüseyin GENÇCELEP, Ömer ZORBA

EFFECTS OF HYDROCOLLOIDS AND CAROB BEAN FLOUR ON RHEOLOGICAL PROPERTIES OF BATTER AND CAKE QUALITY

Serpil ŞAHİN, Servet Gülüm ŞUMNU, Eda BERK

ÇEŞİTLİ FIRINCILIK ÜRÜNLERİNİN HİDROKSİMETİLFURFURAL İÇERİĞİ, ANTİOKSİDAN AKTİVİTESİ VE KOLORİMETRİK ÖZELLİKLERİ ARASINDAKİ İLİŞKİLER

Müge Hendek Ertop, Sevim Beyza Öztürk Sarıkaya